Study on disinfection and prevention of browning in tissue culture of black walnut

doi:10.6048/j.issn.1001-4330.2023.06.024

Abstract

Abstract:

【Objective】 The optimal time for disinfection and the optimal concentration of anti-browning agent were screened out, and the changes in the cell structure of the explants during the browning process will be discussed in the hope of providing theoretical basis for tissue culture research and industrial seedling of black walnut.【Methods】 The leaves and stems of black walnut were disinfected with different lengths of time to observe their effects on the pollution rate and browning rate. Three anti-browning agents, including AC, PVP and VC, were used in orthogonal experiments to study their effects on the browning rate and germination rate of black walnut stems. After that, freehand section of the browned explants was observed.【Results】 (1) When leaves were disinfected with 0.1%HgCl₂ for 5 min, the contamination rate and browning rate were the lowest. (2) When the stem segment was disinfected with 0.1%HgCl₂ and tween 80 for 5 min, the contamination rate and browning rate were the lowest by the two-step sterilization. (3) Treatment with AC 2 g/L, PVP 110 mg/L, VC 100 mg/L had the lowest browning rate and the germination rate of AC 1 g/L, PVP 70 mg/L and VC 50 mg/L was the highest.【Conclusion】 The best disinfection time is to disinfect the leaves with 0.1%HgCl₂ for 5 minutes. The best disinfection time is to disinfect the stem segment with 0.1%HgCl₂ plus tween 80 for 5 min by the two-step sterilization. The most suitable anti-browning agent concentration ratio is AC 1 g/L, PVP 110 mg/L, VC 100 mg/L.

Key words: black walnut; tissue culture; browning; pollution; young stem

摘要：

【目的】筛选出消毒的最佳时间和抗褐化剂的最适浓度,研究外植体细胞结构在褐化过程中的变化,为黑核桃的组培研究和工厂化育苗提供理论基础。【方法】采用不同时长对黑核桃叶片和茎段进行消毒处理,观察其对污染率、褐化率的影响;以AC、PVP、VC 3种抗褐化剂进行正交试验,研究其对黑核桃茎段褐化率和萌发率的影响;观察褐化外植体徒手切片。【结果】 (1)叶片以0.1%HgCl₂消毒5 min,污染率和褐化率最低;(2)茎段以二次消毒法,0.1%HgCl₂加吐温80消毒5 min,污染率和褐化率最低;(3)以AC 2 g/L、PVP 110 mg/L、VC 100 mg/L处理的褐化率最低;以AC 1 g/L、PVP 70 mg/L、VC 50 mg/L处理的萌发率最高。【结论】叶片以0.1%HgCl₂消毒5min为最佳消毒时间;茎段以二次消毒法,0.1%HgCl₂加吐温80消毒5 min为最佳消毒时间;最适的抗褐化剂浓度配比为AC1g/L、PVP 110 mg/L、VC100 mg/L。

关键词: 黑核桃, 组织培养, 褐化, 污染, 幼嫩茎段

CLC Number:

S664.1

FU Qiang, WANG Qin, XU Caiqin, NIU Junli, NIU Jianxin, WANG Jianyou. Study on disinfection and prevention of browning in tissue culture of black walnut[J]. Xinjiang Agricultural Sciences, 2023, 60(6): 1499-1505.

付强, 王琴, 徐彩芹, 牛俊丽, 牛建新, 王建友. 黑核桃组培中消毒及防止褐化最适浓度分析[J]. 新疆农业科学, 2023, 60(6): 1499-1505.

Figures/Tables 7

References 27

[1]	裴东, 吴燕民, 奚声柯. 美国黑核桃的栽培及在我国的发展前景[J]. 河北林果研究, 2000,(1): 95-100.
	PEI Dong, WUYanmin, XU Shengke. Cultivation of American black walnut and its development prospect in China[J]. Hebei Forest and Fruit Research, 2000,(1):95-100.
[2]	Danh C, Zhentian Lei, et al. Identification and quantification of phytosterols in black walnut kernels[J]. Journal of Food Composition and Analysis, 2019, (75):61-69.
[3]	马庆国, 乐佳兴, 宋晓波, 等. 新中国果树科学研究70年——核桃[J]. 果树学报, 2019, 36(10): 1360-1368.
	MA Qingguo, LE Jiaxing, SONG Xiaobo, et al. 70 years of fruit tree scientific research in New China - walnut[J]. Journal of Fruit Trees, 2019, 36(10):1360-1368.
[4]	Licea-Moreno R J, Contreras A, Morales A V, et al. Improved walnut mass micropropagation through the combined use of phloroglucinol and FeEDDHA[J]. Plant Cell, Tissue and Organ Culture (PCTOC), 2015, 123(1):143-154.
[5]	Stevens, Micah, E, et al. Rapid in vitro shoot multiplication of the recalcitrant species Juglansnigra L.[J]. In Vitro Cellular & Developmental Biology, 2018, 54(3):309-317.
[6]	Tuan P N, Meier Dinkel A, Höltken A M, et al. Factors affecting shoot multiplication and rooting of walnut (Juglansregia L.) in vitro[J]. Acta Horticulturae, 2017,(1155):525-530.
[7]	Vahdati K, Ajamgard F, Rahemi M, et al. Advances in Micropropagation of Commercial Pecan Cultivars[J]. International Journal of Fruit Science, 2020:1-12.
[8]	刘淑兰, 韩碧文. 核桃(Juglansregia L.)的离体繁殖[J]. 北京农业大学学报, 1986,(2):143-148.
	LIU Shulan, HAN Biwen. In vitro propagation of Juglansregia L.[J]. Journal of Beijing Agricultural University, 1986,(2):143-148.
[9]	袁巧平, 董茂山. 核桃的组织培养[J]. 植物生理学通讯, 1990,(2):43-44.
	YUAN Qiaoping, DONG Maoshan. Tissue culture of walnut[J]. Plant Physiology Communication, 1990,(2):43-44.
[10]	汤浩茹, 王永清, 任正隆, 等. 德国核桃‘No.120’幼胚胚轴与子叶体细胞胚胎发生及其植株再生[J]. 园艺学报, 2000,(1):59-61.
	TANG Haoru, WANG Yongqing, REN Zhenglong, et al. Somatic embryogenesis and plant regeneration of young embryo hypocotyl and cotyledon of German walnut 'No. 120'[J]. Journal of Horticulture, 2000,(1):59-61.
[11]	王清民, 彭伟秀, 吕保聚. 核桃试管不定根的组织学研究[J]. 西北植物学报, 2006,(4):719-724.
	WANG Qingmin, PENG Weixiu, LV Baoju. Histological study on adventitious roots of Walnut in vitro[J]. Journal of Northwest botany, 2006,(4):719-724.
[12]	Tarinejad A. Effects of disinfectants and antibiotics on contamination during propagation of walnut (Juglansregia L.)[J]. Research on Crops, 2013, 14(1):219-225.
[13]	宋锋惠, 史彦江, 卡德尔. 美国黑核桃组织培养技术[J]. 经济林研究, 2004,(1):22-24.
	SONG Fenghui, SHI Yanjiang Kader Tissue culture technology of American black walnut[J]. Economic Forest Research, 2004,(1): 22-24.
[14]	张建成, 吴国良, 屈红征, 等. 培养基及培养条件对核桃试管芽苗继代增殖的影响[J]. 山西农业大学学报(自然科学版), 2005,(1):45-48.
	ZHANG Jiancheng, WU Guoliang, QU Hongzheng, et al. Effects of culture medium and culture conditions on Subculture and proliferation of walnut tube buds[J]. Journal of Shanxi Agricultural University (Natural Science Edition), 2005,(1):45-48.
[15]	李颖, 李春燕. 多菌灵和青霉素在组培污染中的应用[J]. 林业科技, 2002,(1):6-8.
	LI Ying, LI Chunyan. Application of Carbendazim and penicillin in tissue culture pollution[J]. Forestry Science and Technology, 2002, (1): 6-8.
[16]	郑小琴, 谭鹏鹏, 冯刚, 等. 薄壳山核桃愈伤组织诱导的优化[J]. 分子植物育种, 2020, 18(11):3704-3712.
	ZHAG Xiaoqin, TAN Pengpeng, FENG Gang, et al. Optimization of callus induction of Caryacathayensis[J]. Molecular Plant Breeding, 2020, 18(11):3704-3712.
[17]	付雪宁, 高洪治, 申耀荣, 等. 红桦组织培养体系的建立[J]. 林业科学研究, 2021, 34(3):194-200.
	FU Xuening, GAO Hongzhi, SHEN Yaorong, et al. Establishment of tissue culture system of Betulaplatyphylla[J]. Forestry Science Research, 2021, 34(3):194-200.
[18]	Zhao S, Wang H, Liu K, et al. The role of JrPPOs in the browning of walnut explants[J]. BMC Plant Biology, 2021, 21(1):9. DOI PMID
[19]	Bosela, M J, Michler, et al. Media effects on black walnut (Juglans nigra L.) shoot culture growth in vitro: evaluation of multiple nutrient formulations and cytokinin types[J]. In Vitro Cell Dev Biol-Plant, 2008, 44(4):316-329. DOI URL
[20]	毛沛琪, 李厚华, 李嫒, 等. 硝酸银对‘凤丹’牡丹愈伤组织褐变过程中酚类物质及相关酶活性的影响[J]. 西北林学院学报, 2018, 33(6):83-88.
	MAO Peiqi, LI Houhua, LI Ai, et al. Effects of silver nitrate on phenols and related enzyme activities during Callus Browning of 'Fengdan' peony[J]. Journal of Northwest Forestry University, 2018, 33(6):83-88.
[21]	肖小君, 罗潼, 王芳. 木本植物组织培养过程中褐变现象及控制措施的研究进展[J]. 江苏农业科学, 2017, 45(16):20-24.
	XIAO Xiaojun, LUO Tong, WANG Fang. Research Progress on Browning phenomenon and control measures in tissue culture of woody plants[J]. Jiangsu Agricultural Sciences, 2017, 45(16): 20-24.
[22]	刘杰, 张希, POUDYAL Bharat Kumar, 等. 梨外植体组培褐变的影响因子及预防措施[J]. 果树学报, 2008,(5):727-731.
	LIU Jie, ZHANG Xi, Poudyal Bharat Kumar, et al. Influencing factors and preventive measures of browning in Pear explants[J]. Journal of Fruit Trees, 2008,(5):727-731.
[23]	Lingmin Dai, Qi Zhou, Li Ruimin, et al. Establishment of a picloram-induced somatic embryogenesis system in Vitisvinifera cv. chardonnay and genetic transformation of a stilbene synthase gene from wild-growing Vitis species[J]. Plant Cell, Tissue and Organ Culture (PCTOC), 2015, 121(2):397-412.
[24]	王娟, 田建保, 贺小红, 等. “金薄香”核桃组培中灭菌及防止褐变的研究[J]. 山西农业大学学报(自然科学版), 2008,(3):290-292.
	WANG Juan, TIAN Jianbao, HE Xiaohong, et al. Study on sterilization and browning prevention of "Jin Bo Xiang" walnut in tissue culture[J]. Journal of Shanxi Agricultural University (Natural Science Ed.), 2008,(3): 290-292.
[25]	章铁, 汪莹. 大别山山核桃组培中防褐变措施的研究[J]. 经济林研究, 2005,(1):21-23.
	ZHANG Tie, WANG Ying. Study on anti browning measures in tissue culture of Dabie hickory[J]. Economic forest research, 2005, (1): 21-23.
[26]	Mir J I, Ahmed N, Itoo H, et al. Technique to minimize phenolics in walnut in vitro culture initiation[J]. Indian Journal of Horticulture, 2017, 74(2):285-287. DOI URL
[27]	汤绍虎, 孙敏, 周启贵, 等. 降低“雪青”梨的外植体褐化研究[J]. 西南农业大学学报(自然科学版), 2005,(2):230-233.
	TANG Shaohu, SUN Min, ZHOU Qigui, et al. Study on reducing explant browning of "Xueqing" pear[J]. Journal of Southwest Agricultural University (Natural Science Ed.), 2005,(2): 230-233.

水平 Levels	抗褐化剂 Anti browning agent
水平 Levels	AC (g/L)	PVP (mg/L)	VC (mg/L)
1	1	70	50
2	1.5	90	100
3	2	110	150

水平 Levels	抗褐化剂 Anti browning agent
水平 Levels	AC (g/L)	PVP (mg/L)	VC (mg/L)
1	1	70	50
2	1.5	90	100
3	2	110	150

处理 Treatment	消毒试剂 Disinfection reagent	消毒时长 Disinfection time (min)	污染率 Pollution rate (%)	褐化率 Browning rate (%)
A₁	0.1%HgCl₂	4	22.22^a	13.89^b
A₂	0.1%HgCl₂	5	11.76^ab	14.71^b
A₃	0.1%HgCl₂	6	11.43^ab	25.71^ab
A₄	0.1%HgCl₂	7	8.11^b	37.84^a

处理 Treatment	消毒试剂 Disinfection reagent	消毒时长 Disinfection time (min)	污染率 Pollution rate (%)	褐化率 Browning rate (%)
A₁	0.1%HgCl₂	4	22.22^a	13.89^b
A₂	0.1%HgCl₂	5	11.76^ab	14.71^b
A₃	0.1%HgCl₂	6	11.43^ab	25.71^ab
A₄	0.1%HgCl₂	7	8.11^b	37.84^a

处理 Treatment	消毒时间 Disinfection time (min)	消毒次数 Disinfection times	污染率 Pollution rate (%)	褐化率 Browning rate (%)
B₁	8	单次	48.48^a	24.24^c
B₂	10	单次	33.33^b	45.45^b
B₃	12	单次	14.29^c	57.14^a
B₄	4	二次	47.22^a	11.11^d
B₅	5	二次	29.41^b	17.65^cd
B₆	6	二次	20.59^c	26.67^c