基于D-101大孔吸附树脂分离纯化新疆石榴皮中的总黄酮

doi:10.6048/j.issn.1001-4330.2019.06.012

新疆农业科学 ›› 2019, Vol. 56 ›› Issue (6): 1095-1103.DOI: 10.6048/j.issn.1001-4330.2019.06.012

• 园艺·林业·生理生化 • 上一篇下一篇

基于D-101大孔吸附树脂分离纯化新疆石榴皮中的总黄酮

孟新涛^{1, 2}, 魏健³, 张婷^{1, 2}, 李德华⁴, 谭归⁴, 朱丽娜⁴, 邵文志⁴, 潘俨^{1, 2}

1.新疆农业科学院农产品贮藏加工研究所, 乌鲁木齐 830091;
2.新疆主要农副产品精深加工工程技术研究中心, 乌鲁木齐 830091;
3.喀什大学生命与地理科学学院,新疆喀什 844006;
4.食品科学与药学学院,新疆农业大学,乌鲁木齐 830052

出版日期:2019-06-20 发布日期:2019-08-08
通信作者: 潘俨(1979-),男,副研究员,博士研究生,研究方向为农产品贮藏加工与保鲜,(E-mail)panyan1590@163.com
作者简介:孟新涛(1985-),女,助理研究员,硕士研究生,研究方向为农产品贮藏加工与保鲜,(E-mail)mengxintao_929@126.com
基金资助:
国家科技支撑项目(2011BAD27B01-01-02);新疆农业科学院青年基金(xjnkq-2015038)

Study on Purification of Total Flavonods from Fruit of Pomegranate Cultivars of Xinjiang by D-101 Macroporous Adsorption Resin

MENG Xin-tao^{1, 2}, WEI Jian³, ZHANG Ting^{1, 2}, LI De-hua⁴, TAN Gui⁴, ZHU Li-na⁴, SHAO Wen-zhi⁴, PAN Yan^{1, 2}

1. Research Institute of Agro-products Storage and Processing, Xinjiang Academy of Agricultural Sciences, Urumqi 830091, China;
2. Research center of Main Agricultural Products Processing Engineering in Xinjiang, Urumqi 830091,China;
3. College of Life and Geography Sciences, Kashi University, Kashi Xinjiang 844006, China;
4. College of Food Sciences and Pharmacy, Xinjiang Agricultural University, Urumqi 830052, China

Online:2019-06-20 Published:2019-08-08
Correspondence author: PAN Yan(1979-),male,doctoral candidate,research associate,engaged in farm product storage and processing, (E-mail)panyan1590@163.com
Supported by:
Supported by National Science and Technology Support Project (2011BAD27B01-01-02) and Outstanding Young Scientific Talent Foundation of Xinjaing Academy of Agricultural Sciences (xjnkq-2015038)

摘要/Abstract

摘要： 【目的】研究采用D-101大孔吸附树脂分离纯化新疆石榴皮中的总黄酮。【方法】以单因素为研究基础,分析温度、pH、吸附穿透曲线及洗脱液浓度、料液比等因素,研究D-101大孔吸附树脂分离纯化石榴皮总黄酮的条件,并找到最佳工艺条件。【结果】D101大孔吸附树脂对石榴皮中黄酮类物质纯化的最佳工艺为:提取液pH为4、温度30℃、料液比1∶4(g/mL)、洗脱液乙醇体积为90%。该工艺富集纯化石榴皮黄酮类物质效果较好,石皮总黄酮的纯度由7.25％提高至17.32％。【结论】能有效的洗脱色素、叶绿素等非目标成分,科学合理的分离纯化石榴皮中总黄酮,且操作简单、安全、成本低廉。

关键词: 石榴; 分离纯化; 黄酮; D-101

Abstract: 【Objective】 In this study, D-101 macroporous adsorption resin was used to separate and purify total flavonods from fruits of pomegranate cultivars from Xinjiang.【Method】 Based on the single factor study, the conditions for the separation and purification of total flavonoids from pomegranate skin by DX101 macroporous adsorption resin were further studied by investigating the temperature, pH, adsorption penetration curve, eluent concentration and ratio of material to liquid, and the optimum technological conditions were found.【Result】The optimal purification conditions were as follows:pH 3-4,temperature of 30℃, material ratio of 1∶4(g/mL), the volume of ethanol in the eluent was 90%. Under this process condition, the purity of total flavonoids in pomegranate peel increased from 7.25% to 17.32%. 【Conclusion】Under this process condition, the non-target ingredients, such as pigment and chlorophyll can be eluted effectively, and the total flavonoids of pomegranate cultivars of Xinjiang can be separated and purified scientifically and reasonably and the operation is simple, safe and of low cost.

Key words: pomegranate; peel; flavonoid; D-101

中图分类号:

孟新涛, 魏健, 张婷, 李德华, 谭归, 朱丽娜, 邵文志, 潘俨. 基于D-101大孔吸附树脂分离纯化新疆石榴皮中的总黄酮[J]. 新疆农业科学, 2019, 56(6): 1095-1103.

MENG Xin-tao, WEI Jian, ZHANG Ting, LI De-hua, TAN Gui, ZHU Li-na, SHAO Wen-zhi, PAN Yan. Study on Purification of Total Flavonods from Fruit of Pomegranate Cultivars of Xinjiang by D-101 Macroporous Adsorption Resin[J]. Xinjiang Agricultural Sciences, 2019, 56(6): 1095-1103.

参考文献 19

[1]	胡淳淳. 石榴不同品种、器官多酚、黄酮、矿质元素含量比较及抗氧化性评价[D]. 保定:河北农业大学, 2010.HU Chun-chun. (2010). Comparison of Polyphenols, Flavanoids and Mineral Elements Content among Organs and Cultivars and Evaluation of Antioxidant Capacity in Pomegranates [D]. Master Dissertation. Agricultural University of Hebei Province, Baoding. (in Chinese)
[2]	邱蓉蓉. 石榴果皮提取物对食品腐败菌的抑菌活性及机理研究[D]. 杭州: 杭州师范大学, 2016.QIU Rong-rong. (2016). Study on antibacterial activity against putrefactive bacteria in food and the mechanism of herbal pomegranate peel extract [D]. Master Dissertation. Hangzhou Normal University, Hangzhou. (in Chinese)
[3]	孟新涛, 潘俨, 许铭强, 等. 随机质心映射优化法(RCO)提取皮亚曼石榴皮中黄酮类化合物[J]. 食品工业科技, 2016, (2): 276-280,286.MENG Xin-tao,PAN Yan,XU Ming-qiang,et al. (2016). Random centroid optimization of flavonoids extraction from Pierman pomegranate [J]. Science and Technology of Food Industry, (2): 276-280,286. (in Chinese)
[4]	许宗运, 蒋慧, 吴静, 等. 石榴皮和石榴渣总黄酮含量的测定[J]. 中国农学通报, 2003,19(3): 72-74.XU Zong-yun, JIANG Hui, WU Jing, et al. (2003). Determination of Flavonoids in Pomegranate Husk and Sediment. Chinese Agricultural Science Bulletin [J]. Chinese Agricultural Science Bulletin, 19(3): 72-74. (in Chinese)
[5]	Rosenblat, M. , Hayek, T. , & Aviram, M. (2006). Anti-oxidative effects of pomegranate juice (pj) consumption by diabetic patients on serum and on macrophages. Atherosclerosis, 187(2):363-371.
[6]	郭红霞,梁亚萍,纪明山,等.大孔吸附树脂纯化紫穗槐果实总黄酮的研究[J].河北农业大学学报,2018,41(4):66-72.GUO Hong-xia, LIANG YA-ping, JI Ming-shan, et al. (2018). Purification of total flavonoids from fruit of Amorpha fruticosa by macroporous adsorption resin [J]. Journal of Hebei Agricultural University, 41(4):66-72. (in Chinese)
[7]	贾夏,杨长军.D-101大孔树脂对大叶冬青叶总黄酮的静态吸附性能研究[J].湖北农业科学,2010,49(11):2 886-2 888.JIA Xia,YANG Chang-jun. (2010). Study on Performance of Adsorption of the Macroreticular Resin for Ilex Latifolia Thunb Flavones [J]. Hubei Agricultural Sciences, 49(11):2,886-2,888. (in Chinese)
[8]	De Pascual-Teresa, S., Santos-Buelga, C., & Rivas-Gonzalo, Julián C. (2000). Quantitative analysis of flavan-3-ols in spanish foodstuffs and beverages. Journal of Agricultural and Food Chemistry, 48(11), 5,331-5,337.
[9]	Nogata, Y. , Sakamoto, K. , Shiratsuchi, H. , Ishii, T. , Yano, M. , & Ohta, H. (2006). Flavonoid composition of fruit tissues of citrus species. Bioscience, Biotechnology and Biochemistry, 70(1):178-192.
[10]	Goulas, V., & Manganaris, G. A. (2012). Exploring the physiochemical content and the antioxidant potential of citrus fruits grown in Cyprus. Food Chemistry, 131(1):39-47.
[11]	崔新梅,张海容.大孔树脂分离纯化败酱草黄酮的研究[J].食品研究与开发,2018,39(20):39-43.CUI Xin-mei,ZHANG Hai-rong. (2018). Study on Separation and Purification of Flavonoids from Patrinia with Macroporous Resin [J]. Food Research and Development, 39(20):39-43. (in Chinese)
[12]	白夺龙,杨开华.大孔吸附树脂分离纯化技术及应用[J]. 药学, 2007, 19(9):96-99.BAI Duo-long, YANG Kai-hua. (2007). Isolation and purification of macroporous adsorption resin and its application [J]. Strait Pharmaceutical Journal, 19(9):96-99. (in Chinese)
[13]	刘湘,汪秋安.天然产物化学[M].北京:化学工业出版社,2005.LIU Xiang, WANG Qiu-an. (2005). Natural product chemistry [M]. Beijin: Chemical Industry Press. (in Chinese)
[14]	张晶,郭璐,赵兴然,等.HPLC测定动物源性食品中倍他米松的残留 [J].河北农业大学学报, 2016,39(6):78-82.ZHANG Jing, GUO Lu, ZHAO Xing-ran, et al. (2016). Determination of betamethasone in animal tissues by high performance liquid chromatography [J]. Journal of Agricultural University of Hebei, 39(6):78-82. (in Chinese)
[15]	徐宽,杨栋梁,刘佳佳,等.大孔树脂纯化萼翅藤总黄酮工艺[J].化学工程,2012,40(9):64-68.XU Kuan,YANG Dong-liang,LIU Jia-jia,et al. (2012). Purification of total flavonoids from calycopteris floribunda leaves by macroporous resins [J]. Chemical Engineering, 40(9):64-68. (in Chinese)
[16]	姚佳,李世正,杜煜,等.大孔树脂分离纯化罗勒叶总黄酮及抗氧化活性研究[J].食品研究与开发,2018,39(20):63-68.YAO Jia,LI Shi-zheng,DU Yu,et al. (2018). Study on Purification with Macroporous Resin and Antioxidant of Total Flavonoids from Ocimum basilicum L. [J]. Food Research and Development, 39(20):63-68. (in Chinese)
[17]	李俊, 刘孟源, 方升平, 等. 大孔吸附树脂分离纯化油橄榄叶总黄酮[J].中成药, 2019, 41(2): 261-265.LI Jun, LIU Meng-yuan, FANG Sheng-ping, et al. (2019).Study on separation and purification of total flavonoids from small thistle with macroporous adsorption resin[J]. Chinese Traditional Patent Medicine, 41(2): 261-265.
[18]	席冬华,张政,魏佳,等.树脂柱层析法分离纯化籽瓜中L-瓜氨酸[J].食品工业科技,2015,36(20):304-308,325.XI Dong-hua,ZHANG Zheng,WEI Jia,et al. (2015). Isolation and purification of L-citrulline in seeding watermelon by resin column chromatography [J]. Science and Technology of Food Industry, 36(20): 304-308,325. (in Chinese)
[19]	张立华. 石榴果皮褐变的生理基础及控制的研究[D]. 泰安:山东农业大学, 2006.ZHANG Li-hua. (2006). Study on physiology and control of scald on pomegranate fruit [D]. Master Dissertation. Shandong Agricultural University, Tai'an. (in Chinese)

基于D-101大孔吸附树脂分离纯化新疆石榴皮中的总黄酮

Study on Purification of Total Flavonods from Fruit of Pomegranate Cultivars of Xinjiang by D-101 Macroporous Adsorption Resin

PDF下载

可视化

摘要/Abstract

引用本文

使用本文

参考文献 19

相关文章 15

编辑推荐

Metrics

[1]	束佳敏, 郭元印, 卫丁一, 刘浩然, 依斯马依力, 黄磊, 何子涵, 姚刚, 戴小华. 野山杏总黄酮对LPS诱导鸡肝炎的影响[J]. 新疆农业科学, 2023, 60(8): 2066-2073.
[2]	刘佳佳, 韩涛. 石榴皮瓤提取物对成年小鼠体重增长及血浆免疫相关指标的影响[J]. 新疆农业科学, 2023, 60(8): 2074-2080.
[3]	李硕, 王娟, 尼格尔热依·亚迪卡尔, 朱金芳, 冯作山, 帕尔哈提·艾尼瓦尔. 不同品种杏果实不同发育期功能性成分变化规律[J]. 新疆农业科学, 2023, 60(5): 1200-1207.
[4]	金科旭, 戴小华, 谷虹霏, 束佳敏, 王天琪, 海婷玉. 大孔树脂纯化野山杏总黄酮工艺[J]. 新疆农业科学, 2022, 59(4): 900-907.
[5]	王仙, 聂石辉, 向莉, 张金汕, 李鹏, 方伏荣. 干旱胁迫对中亚大麦农艺性状、产量和品质的影响[J]. 新疆农业科学, 2022, 59(1): 86-94.
[6]	戴小华, 谷虹霏, 金科旭, 束佳敏, 杨若蓝, 吴梦岚, 潘慧, 赵红琼. 应用RP-HPLC法测定野山杏果肉黄酮类化合物[J]. 新疆农业科学, 2021, 58(8): 1476-1485.
[7]	靳元元, 马生军, 徐万里, 张军, 耿阳, 吴文平, 王雪双. 不同产地黄芪活性成分与硒含量比较分析[J]. 新疆农业科学, 2021, 58(5): 873-881.
[8]	孟新涛, 魏健, 许铭强, 李德华, 谭归, 朱丽娜, 邵文志, 潘俨. 高效液相色谱法测定不同品种石榴皮中5种类黄酮的含量[J]. 新疆农业科学, 2019, 56(9): 1659-1667.
[9]	杨磊,靳娟,樊丁宇,赵国庆,杨宏顺,郝庆. 新疆石榴果实品质主成分分析[J]. 新疆农业科学, 2018, 55(2): 262-268.
[10]	吴忠红;张平;阿塔乌拉·铁木尔;张婷;车凤斌;吴斌. 咪鲜胺对新疆喀什石榴贮藏品质的影响[J]. , 2015, 52(1): 20-25.
[11]	曹静;白羽嘉;曹艳;郑杰;段继华;冯作山. 响应面法优化啤酒花茎梗总黄酮微波提取工艺[J]. , 2014, 51(10): 1869-1877.
[12]	李左龙;赛福丁·阿不拉;斯坎达尔·买合木提;阿里木江·阿不力孜. 石榴皮多糖对小鼠免疫功能的影响[J]. , 2013, 50(9): 1711-1717.
[13]	王丽敏;郑灿龙;高贵良;杨平;陈建新;李峰. 大孔吸附树脂分离纯化月见草叶总黄酮工艺研究[J]. , 2013, 50(12): 2286-2295.
[14]	边梅娜;李松泽;白红进;刘帮磊;李春. 响应面法优化赤霞珠葡萄叶总黄酮的提取工艺[J]. , 2013, 50(11): 2037-2045.
[15]	周晓明;闫鹏;马凯;卢春生. 响应面法优化超声波辅助提取玛咖总黄酮的工艺研究[J]. , 2012, 49(8): 1414-1420.