新疆农业科学 ›› 2019, Vol. 56 ›› Issue (3): 544-550.DOI: 10.6048/j.issn.1001-4330.2019.03.018

• 棉花化肥农药减施研究 • 上一篇    下一篇

不同曲面分禾器对分禾的影响及其作业受力分析

易哲田1, 温浩军1,2, 潘佛雏1   

  1. 1.石河子大学机械电气工程学院,新疆石河子 832000;
    2. 农业部西北农业装备重点实验室,新疆石河子 832000
  • 收稿日期:2018-12-12 出版日期:2019-03-20 发布日期:2019-06-25
  • 通信作者: 温浩军,博士生导师,,(E-mail)547273950@qq.com
  • 作者简介:易哲田,硕士研究生,研究方向为农业机械,(E-mail)yizhetian@cctv.admin.edu.pl
  • 基金资助:
    国家重点研发计划(2016YFD0200705,2017YFD0201904)

Influence of Different Curved Surface Graft Dividers on Graft Distribution and Analysis of Their Working Force

YI Zhe-tian1, WEN Hao-jun1,2, PAN Fo-chu1   

  1. 1. School of Mechanical and Electrical Engineering, Shihezi University, Shihezi Xinjiang 832000, China;
    2. Key Laboratory of Agricultural Equipment in Northwest China, Ministry of Agriculture, Shihezi Xinjiang 832000, China
  • Received:2018-12-12 Online:2019-03-20 Published:2019-06-25
  • Correspondence author: Wen Hao-jun, Ph.D. supervisor,(E-mail) 547273950@qq.com
  • Supported by:
    Supported by the National Key R & D Program (2016YFD0200705 and 2017YFD0201904)

摘要: 目的 研究棉花密植栽培模式下,雾滴无法穿透棉花冠层,影响植株中下部受药效果,研究不同曲面分禾器对分禾的影响及其作业受力分析。方法 建立以数学理论为基础的数字化模型,对分禾器工作瞬态作受力分析、棉枝弹性形变分析。结果 在相同扰动情况下,抛物线曲面上同一作用力对分禾曲面造成的压力逐渐减小,在分禾器末端降至23N。结论 抛物线曲面分禾器在通过阻力最低,为三种分禾器中效果最佳的分禾型式。

关键词: 棉花; 分禾器; 密植; 冠层; 弯曲弹性模量

Abstract: Objective To solve the problems caused by dense planting and cultivation mode of cotton in Xinjiang. For example, the fog droplets could not penetrate the crop canopy and the effect of insecticides on the middle and lower parts of cotton plants was poor.Method Through the establishment of a digital model based on mathematical theory, the transient stress analysis of the grain divider and the elastic deformation analysis of cotton branch were carried out.Results Under the same disturbance, the pressure on the splitting surface caused by the same force on the parabolic surface decreased gradually, and it dropped to 23N at the end of the divider. Conclusion The parabolic surface divider has the lowest passing resistance and is the best dividing type among the three dividers.

Key words: cotton ; rice divider; dense planting; cotton canopy; bending modulus of elasticity

中图分类号: 


ISSN 1001-4330 CN 65-1097/S
邮发代号:58-18
国外代号:BM3342
主管:新疆农业科学院
主办:新疆农业科学院 新疆农业大学 新疆农学会

出版单位:《新疆农业科学》编辑部
地址:乌鲁木齐市南昌路403号新疆农业科学院
邮编:830091
电话:0991-4502046
E-mail:xjnykx-h@xaas.ac.cn


版权所有 © 《新疆农业科学》编辑部
本系统由北京玛格泰克科技发展有限公司设计开发
总访问量: 今日访问: 在线人数:
网站
微信公众号
淘宝购买
微店购买